Adsorpsi Metilen Biru dan Kongo Merah pada Zeolit-A Hasil Sintesis dari Abu Dasar Batubara PT. Petrokimia Gresik
DOI:
https://doi.org/10.32487/jst.v8i1.1283Abstract
The adsorption of methylene blue and congo red dye using zeolite-A synthesized from coal bottom ash and it comparison from synthetic materials has been studied with initial concentration variations between 60, 80, 100, 120, 140, 160, 180, 200 and 220 mg/L, contact time 10-100 min and temperature between 30, 40, 50 ºC with pH 6-7. Adsorption equilibrium time was achieved at contact time of 70-80 minutes for methylene blu dye and 40-50 minutes for congo red dye. Increased adsorption capacity significantly lead to methylene blue with maximum adsorption capacity achieved up to 67.57 mg/g and 70.73 mg/g, adsorption capacity on congo red adsorbate achieved 39.43 mg/g and 41.50 mg/g each for zeolite A from coal bottom ash and it comparison. The analysis of the kinetics adsorption equation shows that the adsorption process of methylene blue and congo red dye follows second-order pseudo kinetics model, but adsorption of methylene blue follows Freundlich isothermal equation, while adsorption of congo red follows Langmuir isothermal equation. The study of adsorption thermodynamics results that the capacity adsorption increased with the increasing of temperature. Adsorption process occurs endothermally and spontaneously at methylene blue and congo red dye.
References
. Daftar Pustaka
Z. Derakhshan, M. A. Baghapour, M. Ranjbar, and M. Faramarzian, “Adsorption of methylene blue dye from aqueous solutions by modified pumice stone: kinetics and equilibrium studies,” 2013.
R. Rahmi and L. Lelifajri, “Influence of heat treatment on eggshell particles as low cost adsorbent for methylene blue removal
from aqueous solution,” Rasayan J. Chem., vol. 10, pp. 634–642, Jun. 2017, doi: 10.7324/RJC.2017.1021736.
J. Shu, Z. Wang, Y. Huang, N. Huang, C. Ren, and W. Zhang, “Adsorption removal of Congo red from aqueous solution by polyhedral Cu2O nanoparticles: kinetics, isotherms, thermodynamics and mechanism analysis,” J. Alloys Compd., vol. 633, pp. 338–346, 2015.
W. Chunfeng, L. I. Jiansheng, W. Lianjun,
S. U. N. Xiuyun, and J. HUANG, “Adsorption of dye from wastewater by zeolites synthesized from fly ash: kinetic and equilibrium studies,” Chinese J. Chem. Eng., vol. 17, no. 3, pp. 513–521, 2009.
Z. Yang et al., “A novel approach for methylene blue removal by calcium dodecyl sulfate enhanced precipitation and microbial flocculant GA1 flocculation,” Chem. Eng. J., vol. 303, pp. 1–13, 2016.
M. S. Mahmoud, J. Y. Farah, and T. E. Farrag, “Enhanced removal of Methylene Blue by electrocoagulation using iron electrodes,” Egypt. J. Pet., vol. 22, no. 1, pp. 211–216, 2013.
M. A. Ahmed, M. F. A. Messih, E. F. El- Sherbeny, S. F. El-Hafez, and A. M. M. Khalifa, “Synthesis of metallic silver nanoparticles decorated mesoporous SnO2 for removal of methylene blue dye by coupling adsorption and photocatalytic processes,” J. Photochem. Photobiol. A Chem., vol. 346, pp. 77–88, 2017.
K. Rida, S. Bouraoui, and S. Hadnine, “Adsorption of methylene blue from aqueous solution by kaolin and zeolite,” Appl. Clay Sci., vol. 83, pp. 99–105, 2013.
T. Robinson, G. McMullan, R. Marchant, and P. Nigam, “Remediation of dyes in textile effluent: a critical review on current treatment technologies with a proposed alternative,” Bioresour. Technol., vol. 77, no. 3, pp. 247–255, 2001.
A. Ahmad, M. Rafatullah, and M. Danish, “Removal of Zn (II) and Cd (II) ions from aqueous solutions using treated sawdust of sissoo wood as an adsorbent,” Holz als Roh-und Werkst., vol. 65, pp. 429–436, 2007.
V. Garshasbi, M. Jahangiri, and M. Anbia, “Equilibrium CO2 adsorption on zeolite 13X prepared from natural clays,” Appl. Surf. Sci., vol. 393, pp. 225–233, 2017.
A. A. Pour, S. Sharifnia, R. NeishaboriSalehi, and M. Ghodrati, “Performance evaluation of clinoptilolite and 13X zeolites in CO2 separation from CO2/CH4 mixture,” J. Nat. Gas Sci. Eng., vol. 26, pp. 1246–1253, 2015.
A. Kongnoo, S. Tontisirin, P. Worathanakul, and C. Phalakornkule, “Surface characteristics and CO2 adsorption capacities of acid-activated zeolite 13X prepared from palm oil mill fly ash,” Fuel, vol. 193, pp. 385–394, 2017.
M. Qiu, C. Qian, J. Xu, J. Wu, and G. Wang, “Studies on the adsorption of dyes into clinoptilolite,” Desalination, vol. 243, no. 1–3, pp. 286–292, 2009.
M. Sarioglu, “Removal of ammonium from municipal wastewater using natural Turkish (Dogantepe) zeolite,” Sep. Purif. Technol., vol. 41, no. 1, pp. 1–11, 2005.
B. Said, T. Cacciaguerra, F. Tancret, F. Fajula, and A. Galarneau, “Size control of self-supported LTA zeolite nanoparticles monoliths,” Microporous Mesoporous Mater., vol. 227, pp. 176–190, 2016.
A. M. Abbas, Y. I. Mohammed, and T. A. Himdan, “Adsorption kinetic and thermodynamic study of congo red dye on synthetic zeolite and modified synthetic zeolite,” Ibn AL-Haitham J. Pure Appl. Sci., vol. 28, no. 1, pp. 54–72, 2017.
H. Auer and H. Hofmann, “Pillared clays: characterization of acidity and catalytic properties and comparison with some zeolites,” Appl. Catal. A Gen., vol. 97, no. 1, pp. 23–38, 1993.
C. D. Williams and C. L. Roberts, “A comparative study of two methods for the synthesis of fly ash-based sodium and potassium type zeolites,” Fuel, vol. 88, no. 8, pp. 1403–1416, 2009.
S. Rayalu, S. U. Meshram, and M. Z. Hasan, “Highly crystalline faujasitic
zeolites from flyash,” J. Hazard. Mater., vol. 77, no. 1–3, pp. 123–131, 2000.
M. Chareonpanich, O. Jullaphan, and C. Tang, “Bench-scale synthesis of zeolite A from subbituminous coal ashes with high crystalline silica content,” J. Clean. Prod., vol. 19, no. 1, pp. 58–63, 2011.
Y. Yanti, “Sintesis Zeolit A dan Zeolit Karbon Aktif dari Abu Dasar PLTU Paiton dengan Metode Peleburan,” Inst. Teknol. Sepuluh Nop. Surabaya, 2009.
S. Mintova, Verified syntheses of zeolitic materials. Synthesis Commission of the International Zeolite Association, 2016.
S. A. L. B. Cu II, “Pemanfaatan Limbah Abu Dasar Batubara sebagai Bahan Dasar Sintesis Zeolit dan Aplikasinya.”
Y. Xiao et al., “Mechanism on solvent-free crystallization of NaA zeolite,” Microporous Mesoporous Mater., vol. 237, pp. 201–209, 2017.
P. Kunecki, R. Panek, M. Wdowin, and W. Franus, “Synthesis of faujasite (FAU) and tschernichite (LTA) type zeolites as a potential direction of the development of lime Class C fly ash,” Int. J. Miner. Process., vol. 166, pp. 69–78, 2017.
A. R. Loiola, J. Andrade, J. M. Sasaki, and
L. R. D. Da Silva, “Structural analysis of zeolite NaA synthesized by a cost-effective hydrothermal method using kaolin and its use as water softener,” J. Colloid Interface Sci., vol. 367, no. 1, pp. 34–39, 2012.
A. Iryani, M. M. Ilmi, and D. Hartanto, “Adsorption study of congo red dye with ZSM-5 directly synthesized from bangka kaolin withouth organic template,” Malaysian J. Fundam. Appl. Sci., vol. 13, no. 4, pp. 832–839, 2017.
D. Karadag, “Modeling the mechanism, equilibrium and kinetics for the adsorption of Acid Orange 8 onto surfactant-modified clinoptilolite: The application of nonlinear regression analysis,” Dye. Pigment., vol. 74, no. 3, pp. 659–664, 2007.
A. R. Abbasi, M. Karimi, and K. Daasbjerg, “Efficient removal of crystal violet and methylene blue from wastewater by ultrasound nanoparticles Cu-MOF in comparison with mechanosynthesis method,” Ultrason. Sonochem., vol. 37, pp. 182–191, 2017
Downloads
Published
Issue
Section
License
Authors submitting a manuscript do so on the understanding that if accepted for publication, copyright of the article shall be assigned to Jurnal Sains Terapan, campus polytechnic country balikpapan, Balikpapan, East Kalimantan as publisher of this journal.
Copyright encompasses exclusive rights to reproduce and deliver the article in all forms and media, including reprints, photographs, microfilms and any other similar reproductions, as well as translations. The reproduction of any part of this journal, its storage in databases and its transmission by any forms or media, such as electronic, electrostatic and mechanical copies, photocopies, recordings, magnetic media, etc., will be allowed only with a written permission from Jurnal Sains Terapan, Campus Polytechnic Country Balikpapan, Balikpapan, East Kalimantan.
Jurnal Sains Terapan, campus polytechnic country Balikpapan, Balikpapan, East Kalimantan, Editorial Board make every effort to ensure that no wrong or misleading data, opinions or statements be published in the journal. In any way, the contents of the articles and advertisements published in Jurnal Sains Terapan are the sole and exclusive responsibility of their respective authors and advertisers.
The Copyright Transfer Agreement Form can be downloaded from this link The copyright form should be filled with respect to article and be signed originally and sent scanned document file (softcopy) and the article to our email, jst@poltekba.ac.id or sent it to the Editorial Office in the form of original hard copy and the article in softcopy form on Flash Disc or Compact Disc, to;
Saiful Ghozi as JST Journal Manager, Pusat Penelitian dan Pengabdian Kepada Masyarakat, Politeknik Negeri Balikpapan, Jl.Soekarno Hatta Km.8, Balikpapan, East Kalimantan.
